News:

Putting FUN and FRIENDLINESS, FIRST into owning and learning about AMC small bodied cars, primarily Eagles, Spirits and Concords as well as vehicles built in AMC's Mexican subsidiary, VAM.

The AMC Eaglepedia can now be accessed using the buttons found below  This is a comprehensive ever growing archive of information, tips, diagrams, manuals, etc. for the AMC Eagle and other small bodied AMC cars. 

Also a button is now available for our Face Book Group page.

Welcome to the AMC Eagles Nest.  A new site under "old" management -- so welcome to your new home for everything related to AMC Eagles, Spirits and Concords along with opportunities to interact with other AMC'ers.  This site will soon be evolving to look different than it has and we will be incorporating new features we hope you will find useful, entertaining and expand your AMC horizons.

You can now promote your topics at your favorite social media site by clicking on the appropriate icon (top upper right of the page) while viewing the topic you wish to promote.

Main Menu

timing after mcu bypass test

Started by jim, September 01, 2011, 09:50:30 PM

Previous topic - Next topic

0 Members and 1 Guest are viewing this topic.

Print
Go Down Pages1
User actions

jim

September 01, 2011, 09:50:30 PM Last Edit: September 01, 2011, 09:55:52 PM by jim
1983 wagon but with a 1980 non-feed back carb.  Mcu test finally done, hopefully correctly.  It did start right up and idle fairly well after bypassing the mcu.
What should the timing be?  600 - 700 ft above sea level.
Do I still need to plug the dist vac and time it at 1600 RPM?

Is the mcu bypass likely to help with the almost-impossible-to-start-when-hot issue?
It starts great when cold, or it did before the bypass.  I hope that doesn't change.
I'm right 98% of the time, and I don't care about the other 3%.
"The constitutions of most of our States assert that all power is inherent in the people;
that... it is their right and duty to be at all times armed."
--Thomas Jefferson to John Cartwright, 1824. ME 16:45
What part of "shall not be infringed" do they not understand?
08 Impala
01 Yukon 4X4
(There's more to life than fuel mileage)
83 Eagle wagon; shared responsibility as daily driver
88 Eagle white woody wagon; shared responsibility as daily driver
86 wagon parts car
<a href="http://www.wunderground.com/US/AR/Little_Rock.html?bannertypeclick=miniStates">Click for Little Rock, AR Forecast" border="0" height="100" width="150

GRONK

#1
September 01, 2011, 10:22:59 PM
remove dist vac and cap the port on the carb/intake
set timing to 9 deg at 650RPM
Hook vacuum up to PORTED vacuum after set (not intake vacuum)
"Bucket" 1983 Limited Wagon
"Tootie" 1984 Wagon
Owner - GRONK Performance

jim

#2
September 01, 2011, 10:51:58 PM
Thanks. 
That's what I needed to know.
I think mine is already on the carb port.  That was done when the motor/carb were installed about 6 or 7000 miles ago.
I'm right 98% of the time, and I don't care about the other 3%.
"The constitutions of most of our States assert that all power is inherent in the people;
that... it is their right and duty to be at all times armed."
--Thomas Jefferson to John Cartwright, 1824. ME 16:45
What part of "shall not be infringed" do they not understand?
08 Impala
01 Yukon 4X4
(There's more to life than fuel mileage)
83 Eagle wagon; shared responsibility as daily driver
88 Eagle white woody wagon; shared responsibility as daily driver
86 wagon parts car
<a href="http://www.wunderground.com/US/AR/Little_Rock.html?bannertypeclick=miniStates">Click for Little Rock, AR Forecast" border="0" height="100" width="150

jim

#3
September 06, 2011, 04:41:38 PM
Well, I got the timing set to 9.  It didn't help the hard starting when warm.  It starts great cold and runs great.
When it doesn't start I can't tell whether it's flooded or starved.  Mostly I think it floods extremely easily, but holding the throttle open doesn't help.
I'm right 98% of the time, and I don't care about the other 3%.
"The constitutions of most of our States assert that all power is inherent in the people;
that... it is their right and duty to be at all times armed."
--Thomas Jefferson to John Cartwright, 1824. ME 16:45
What part of "shall not be infringed" do they not understand?
08 Impala
01 Yukon 4X4
(There's more to life than fuel mileage)
83 Eagle wagon; shared responsibility as daily driver
88 Eagle white woody wagon; shared responsibility as daily driver
86 wagon parts car
<a href="http://www.wunderground.com/US/AR/Little_Rock.html?bannertypeclick=miniStates">Click for Little Rock, AR Forecast" border="0" height="100" width="150

GRONK

#4
September 06, 2011, 06:08:26 PM
Check your power valve (make sure there is no fuel inside the cover.  Maybe try lowering your float just a little bit.  Maybe think of insulating the base of the carb from heat? (Thick thermal gasket)

Your choke isn't closing when warm is it?  Could be a fast idle adjustment too.

Can you send me pics of your install?

[email protected]
"Bucket" 1983 Limited Wagon
"Tootie" 1984 Wagon
Owner - GRONK Performance

jim

#5
September 06, 2011, 07:59:00 PM
We'll be leaving before daylight tomorrow morning, so I won't be able to get a picture any time soon.  My choke does sometimes close when it's warm, but not always.  When it does close, it seems to be stuck and takes a small tap to make it open.  After several tries it will sometimes backfire, and then after just a couple more tries it will start.
I don't know about the power valve.
I'm right 98% of the time, and I don't care about the other 3%.
"The constitutions of most of our States assert that all power is inherent in the people;
that... it is their right and duty to be at all times armed."
--Thomas Jefferson to John Cartwright, 1824. ME 16:45
What part of "shall not be infringed" do they not understand?
08 Impala
01 Yukon 4X4
(There's more to life than fuel mileage)
83 Eagle wagon; shared responsibility as daily driver
88 Eagle white woody wagon; shared responsibility as daily driver
86 wagon parts car
<a href="http://www.wunderground.com/US/AR/Little_Rock.html?bannertypeclick=miniStates">Click for Little Rock, AR Forecast" border="0" height="100" width="150

GRONK

#6
September 07, 2011, 08:35:30 AM
The choke should never be closed when warm.  Might need to add another gasket behind the choke cap to space it away from the choke housing (If the choke tang is rubbing on the cap)
"Bucket" 1983 Limited Wagon
"Tootie" 1984 Wagon
Owner - GRONK Performance

jim

#7
September 07, 2011, 09:56:39 PM
After much trouble at the first pit stop I may have stumbled on a work around.  If it doesn't start right away I close the choke and turn it over, open the choke and turn it over a time or 3 and it starts.  It has worked 3 or 4 times.  It sometimes backfires a time or 2 first and then starts.

Once again it starts great when cold and runs great once it starts.  We made 700 miles today with no problems except for starting.
I'm right 98% of the time, and I don't care about the other 3%.
"The constitutions of most of our States assert that all power is inherent in the people;
that... it is their right and duty to be at all times armed."
--Thomas Jefferson to John Cartwright, 1824. ME 16:45
What part of "shall not be infringed" do they not understand?
08 Impala
01 Yukon 4X4
(There's more to life than fuel mileage)
83 Eagle wagon; shared responsibility as daily driver
88 Eagle white woody wagon; shared responsibility as daily driver
86 wagon parts car
<a href="http://www.wunderground.com/US/AR/Little_Rock.html?bannertypeclick=miniStates">Click for Little Rock, AR Forecast" border="0" height="100" width="150
Print
Go Up Pages1
User actions
SMF spam blocked by CleanTalk